North Carolina-class battleship


The North Carolina class was a class of two fast battleships, and, built for the United States Navy in the late 1930s and early 1940s. The Navy was originally uncertain whether the ships should be fast enough to counter the Japanese, which was believed by the United States to be capable of, or should sacrifice speed for additional firepower and armor. The 1936 Second London Naval Treaty's requirement that all capital ships have a standard displacement of under prevented the desired objectives from being fully realized within its limits, and the navy considered over fifty designs before one was chosen.
Towards the end of this lengthy design period the General Board of the United States Navy declared its preference for a battleship with a speed of, faster than any in US service or under construction, with a main battery of nine /50 caliber Mark B guns. The board believed that such ships could fulfill a multitude of roles, as they would have enough protection to be put into a battle line while also having enough speed to escort aircraft carriers or engage in commerce raiding. However, the acting Secretary of the Navy authorized a modified version of a different design, which in its original form had been rejected by the General Board. This called for a ship with twelve 14-inch guns in quadruple turrets and protection against guns of the same caliber. In a major departure from traditional American design practices, this design accepted lower speed and protection in exchange for maximum firepower. After construction had begun, the United States became concerned over Japan's refusal to commit to the caliber limit of the Second London Naval Treaty, so they invoked the "escalator clause" of that pact and increased the class' main armament to nine /45 caliber Mark 6 guns from the original twelve 14-inch guns.
Both North Carolina and Washington saw extensive service during the Second World War in a variety of roles, primarily in the Pacific Theater where they escorted fast carrier task forces and conducted shore bombardments. North Carolina shot down between seven and fourteen Japanese aircraft in the Battle of the Eastern Solomons, and later sustained a torpedo hit from a Japanese submarine. In a chaotic night engagement during the naval battle of Guadalcanal Washingtons radar-directed main batteries fatally damaged the Japanese battleship, causing it to sink the next day. In February 1944, Washington crushed its bow in a collision with battleship. Following repairs, Washington rejoined North Carolina for the Battle of the Philippine Sea. After the end of the war, both ships took part in Operation Magic Carpet, the withdrawal of American military personnel from overseas deployments. The vessels were laid up in the reserve fleet until the early 1960s, when North Carolina was sold to the state of North Carolina as a museum ship, and Washington was broken up for scrap.

Background

After the end of the First World War, several navies continued and expanded naval construction programs that they had started during the conflict. The United States' 1916 program called for six s and five battleships; in December 1918, the administration of President Woodrow Wilson called for building an additional ten battleships and six battlecruisers. The 1919–1920 General Board proposals planned for slightly smaller, but still significant, acquisitions beyond the 1916 plan: two battleships and a battlecruiser for the fiscal year 1921, and three battleships, a battlecruiser, four aircraft carriers and thirty destroyers between the fiscal years 1922 and 1924. The United Kingdom was in the final stages of ordering eight capital ships. Imperial Japan was, by 1920, attempting to build up to an 8-8 standard of eight battleships and eight battlecruisers or cruisers with the,,, and classes. Two ships from these designs would be laid down per year until 1928.
With the staggering costs associated with such programs, the United States' Secretary of State Charles Evans Hughes invited delegations from the major maritime powers—France, Italy, Japan, and the United Kingdom—to come together in Washington, D.C. to discuss, and hopefully end, the naval arms race. The subsequent Washington Naval Conference resulted in the 1922 Washington Naval Treaty. Along with many other provisions, it limited all future battleships to a standard displacement of and a maximum gun caliber of 16-inch. It also decreed that the five countries could not construct another capital ship for ten years and could not replace any ship that survived the treaty until it was at least twenty years old.
The 1936 Second London Naval Treaty, while superseding the 1922 agreement, nonetheless kept many of the same requirements, though it restricted gun size on new warships to 14-inch. These treaties heavily influenced the design of the North Carolina class, as can be attested to in the long quest to find a ship that incorporated everything considered necessary while remaining under 35,000 long tons.

Design

Early

The General Board began preparations for a new class of battleships in May–July 1935. Three design studies were submitted to them: "A" would be armed with nine guns in triple turrets—all forward of the bridge—capable of 30–knots, and armored against 14-inch shells; "B" and "C" would both be over, able to reach and armored against 14-inch shells—the major difference between the two was the planned main battery, as "B" had twelve 14-inch guns in triple turrets, while "C" had eight 16-inch/45-caliber guns in dual turrets. "A" was the only one to remain within the 35,000–tons displacement limit set in the Washington Naval Treaty and reaffirmed in the Second London Naval Treaty. When the Bureau of Ordnance introduced a "super-heavy" 16-inch shell, the ships were redesigned in an attempt to provide protection against it, but this introduced severe weight problems: "A1" was only below the 35,000-ton limit, while the other two were close to.
Although these original three studies were all fast battleships, the General Board was not definitively committed to the higher maximum speeds. It posed questions to the Naval War College, asking for their opinion as to whether the new class should be a "conventional" ship with an eight-nine, 16-inch main battery, or rather one akin to "A", "B" or "C".
Five more design studies were produced in late September 1935, which had characteristics of 23–30.5 knots, eight or nine 14- or 16-inch guns, and a standard displacement between. Designs "D" and "E" were attempts at fast battleships with 16-inch guns and protections against the same, but their displacement was greater than the Washington Naval Treaty allowed. Design "F" was a radical attempt at a hybrid battleship-carrier, with three catapults mounted fore and eight 14-inch guns aft. It was reportedly favored by President Franklin Delano Roosevelt, but as aircraft launched from catapults were necessarily inferior to most carrier- or land-based aircraft because of the floats used to land, nothing came of the design. Designs "G" and "H" were slower 23-knot ships with nine 14-inch guns; in particular, "H" was thought to be a very well balanced design by the Preliminary Design section of the Bureau of Construction and Repair. However, the General Board finally decided to use faster ships, which "G" and "H" were not.
These studies demonstrated the difficulty the designers faced. With a displacement of 35,000 tons, there were two basic choices: a ship similar to "A1" which was faster but more lightly armed and armored than contemporary battleships or one which was slower but armed with heavier guns—although fitting in protection against 16-inch guns would be extremely difficult. Preliminary Design drew up five more studies in October, based upon either "A" with additional armor or a scaled-down "B"; all utilized 14-inch guns and called for 30 or 30.5 knots. Two called for four turrets, but this would be too heavy and mount less armor. Another, "K," belt and deck and a immune zone against the United States' super-heavy 14-inch shell. While "K" was liked by the naval constructors, its designed standard displacement of 35,000 tons left little room for error or any modifications and improvements to the design. A final two, "L" and "M," would use quadruple turrets to save weight while still mounting 12 guns.
Many officers in the United States Navy supported the construction of three or four battlecruiser-type ships for carrier escorts and to counter Japan's. These included the acting Secretary of the Navy and Chief of Naval Operations Admiral William Standley, the president of the Naval War College Admiral William S. Pye, a small majority of senior officers at sea, and five of six line officers engaged in strategic planning as part of the War Plans Division, although at least one officer believed that an aerial attack would also be capable of sinking the Kongōs. With the above recommendations, the General Board selected "K" to undergo further development.

Final

At least 35 different final designs were proposed. All numbered with Roman numerals, the first five were completed on 15 November 1935. They were the first to employ so-called "paper" weight reductions: not counting certain weights in the ship's 35,000 long ton limit that were not specifically part of the definition of standard displacement. In this case, even though there was designed storage room for 100 shells per main battery gun and an extra 100 rounds, the weight of the rounds did not figure toward the treaty-mandated limit.
These designs varied greatly in everything but their standard displacements and speeds. "II" called for, every other design called for 35,000 long tons, and only five planned for a top speed of under ; of those, only one was lower than : "VII", with. "VII" returned to a lower speed to obtain more firepower and protection; as such, the design called for only and a length of only. Most other plans called for or, although six had lengths between and. The first eight designs carried nine 14-inch guns, but many other combinations were tried, including eight 14-inch in two quadruple turrets, eight 14-inch guns in four dual turrets, and ten, eleven or twelve 14-inch guns.
The "XVI" version of 20 August 1936 was a, ship that the Bureau of Ordnance found many problems in. Model tests showed at high speeds, waves generated by the design of the hull would leave some lower parts of the ship uncovered—including the magazines. To complicate the issue, the Bureau found low or underwater shell hits could be a serious problem when fighting at ranges between. Other problems included the design's defense against aircraft-dropped bombs, as the Bureau thought the formula used to calculate its effectiveness was not realistic; and the tapering of a fore bulkhead below the waterline could worsen underwater shell hit problems because the mostly unarmored bow could easily be penetrated. The solutions for these issues were all impractical; added patches of armor around the magazines could neutralize the torpedo-defense system's effectiveness, and deepening the belt near the bow and stern would put the ships over the 35,000 long ton limit. The General Board detested this design, saying it was "not... a true battleship" due to its speed and armor problems.
To address these problems, a final set of designs, "XVI-B"–"XVI-D", was presented by Preliminary Design in October 1936. They were modifications of the "XVI" plan for a ship that was 714 ft. long, had twelve guns in three quadruple turrets, a belt of sloped at °, and a deck thick. In the final set, length was fixed at for greater speed, but this meant only eleven 14-inch guns could be mounted with a thin belt. Alternatively, one gun could be traded for a belt, and another could be swapped for a 30-knot speed and one more tenth of an inch of belt armor; this became design "XVI-C". The General Board liked "XVI-C" very much, seeing in it a ship that had enough protection to fight—and survive—in a battle line formed with the older battleships while also having enough speed to operate in a detached wing with, for example, aircraft carrier or cruiser commerce raiding groups.
However, one member of the Board, Admiral Joseph Reeves—who had previously been one of the principal developers of the United States' aircraft carrier strategy—disliked "XVI-C" because he believed that it was not fast enough to work with the fast carriers, and it was not powerful enough to justify its cost. Instead, he advocated a development of the previously rejected "XVI", adding additional underwater protection and patches of armor within the ship to make the magazines immune to above- and below-water shell hits from and beyond. The immune zone's outer limit was increased from to. After further revisions, Reeves went to Standley, the Chief of Naval Operations, who approved "XVI" in its newly modified form over the hopes of the General Board, who still thought that "XVI-C" should be built. Standley's only addition to the characteristics was provision for a switch from quadruple 14-inch to triple turrets if the "escalator clause" in the Second London Naval Treaty was invoked.

The "escalator clause"

Although the Second London Naval Treaty stipulated that warship guns could be no larger than 14 inches, a so-called "escalator clause" was included at the urging of American negotiators in case any country that had signed the Washington Naval Treaty refused to adhere to this new limit. The provision allowed signatory countries of the Second London Treaty—France, the United Kingdom and the United States—to raise the limit from 14 to 16 inches if Japan or Italy still refused to sign after 1 April 1937. When figuring potential configurations for the North Carolinas, designers focused most of their planning on 14-inch weaponry; Standley's requirement meant that a switch from 14- to 16-inch, even after the ships' keels had been laid, was possible. Japan formally rejected the 14-inch limit on 27 March 1937, meaning that the "escalator clause" could be invoked. There were hurdles that still needed to be overcome, though: Roosevelt was under heavy political pressure and, as a result, was reluctant to allow the 16-inch gun.
Admiral Reeves also came out strongly in favor of the larger weapon. In a two-page letter to Secretary of the Navy Claude A. Swanson and indirectly to Roosevelt, Reeves argued that the 16-inch gun's significantly greater armor penetration was of paramount importance, drawing examples from the First World War's Battle of Jutland, where some battleships were able to survive ten or twenty hits from large guns, but other battlecruisers were blown up in three to seven hits because the shells were able to cut through the armor protecting magazines and turrets. Reeves also argued that the larger gun would favor the "indirect method" of shooting then being developed, where airplanes would be used to relay targeting information to allied battleships so that they could bombard targets that were out of their sight or over the horizon, because new battleships being built by foreign powers would have more armor. Reeves believed that if the 14-inch gun was adopted, it would not be able to penetrate this larger amount of protection, whereas the 16-inch would be able to break through.
In a final vain attempt, Roosevelt's Secretary of State Cordell Hull sent a telegram on 4 June to the Ambassador to Japan Joseph Grew instructing him that the United States would still accept a cap of 14-inch guns if he could get Japan to as well. The Japanese replied that they could not accept this unless the number of battleships was also limited; they wanted the United States and the United Kingdom to agree to having an equal number of battleships with Japan, but this was a condition that the two countries refused to accept. On 24 June, the two North Carolinas were ordered with the 14-inch weapons, but on 10 July, Roosevelt directed that they be armed with triple 16-inch instead.

Specifications

General characteristics

The North Carolina was long at the waterline and long overall. The maximum beam was while waterline beam was due to the inclination of the armor belt. In 1942, the standard displacement was while full load displacement was, while maximum draft was. At design combat displacement of, the mean draft was and metacentric height was. As designed, the crew complement was 1,880 with 108 officers and 1,772 enlisted. By 1945, the considerable increase in anti-aircraft armament and their crew accommodations had increased full load displacement to, while crew complement increased to 2,339 with 144 officers and 2,195 enlisted. After the end of World War II, the crew complement was reduced to 1,774.
The North Carolina class hull feature a bulbous bow and had an unusual stern design for the time by placing the two inboard propulsion shafts in skegs. This was theorized to improve flow conditions to the propellers. Initial model basin testing for various stem configurations suggested that the skeg arrangement could reduce resistance, although later testing during the design process of the battleship would indicate an increase in drag. The skegs improved the structural strength of the stern by acting as girders and also provided structural continuity for the torpedo bulkheads. However, the skegs also contributed to severe vibration problems with the class that required extensive testing and modifications to mitigate. The problem was particularly acute near the aft main battery director, which required additional reinforcing braces due to the vibrations. Nevertheless, skegs would be improved and incorporated in the designs of all subsequent American battleships, with vibration problems largely eliminated on the Iowa class battleships.

Armament

North Carolina and Washington were principally armed with nine /45 caliber Mark 6 guns and twenty /38 cal Mark 12 guns. Their lighter armament consisted of varying numbers of /75 caliber,.50 caliber machine guns, Bofors 40 mm and Oerlikon 20 mm.

Main battery

Mounted on both the North Carolina class and the follow-up, the nine 16 in/45 were improved versions of the guns mounted on the s, hence the designation of "Mark 6". A major alteration from the older guns was the Mark 6's ability to fire a new armor-piercing shell developed by the Bureau of Ordnance. At full charge with a brand-new gun, the heavy shell would be expelled at a muzzle velocity of. At a reduced charge, the same shell would be fired at. Barrel life—the approximate number of rounds a gun could fire before needing to be relined or replaced—was 395 shells when using AP, although if only practice shells were used this figure was significantly higher: 2,860. Turning at 4 degrees a second, each turret could to 150 degrees on either side of the ship. The guns could be elevated to a maximum inclination of 45 degrees; turrets one and three could depress to −2 degrees, but due to its superfiring position, the guns on turret two could only depress to 0 degrees.DiGiulian, "16"/45 Mark 6"
Each gun was long overall; its bore and rifling length were and, respectively. Maximum range with the heavy AP shell was obtained at an inclination of 45 degrees:. At the same elevation a lighter high capacity shell would travel. The guns weighed not including the breech; the turrets weighed slightly over.
When firing the same shell, the 16-inch/45 Mark 6 had a slight advantage over the 16-inch/50 Mark 7 when hitting deck armor—a shell from a 45 cal gun would be slower, meaning that it would have a steeper trajectory as it descended. At, a shell from a 45 cal would strike a ship at an angle of 45.2 degrees, as opposed to 36 degrees with the 50 cal.

Secondary battery

The North Carolinas carried ten Mark 28 Mod 0 enclosed base ring mounts, each supporting twin 5-inch/38 caliber Mark 12 gunsDiGiulian, Originally designed to be mounted on destroyers built in the 1930s, these guns were so successful that they were added to a myriad of American ships during the Second World War, including every major ship type and many smaller warships constructed between 1934 and 1945. They were considered to be "highly reliable, robust and accurate" by the Navy's Bureau of Ordnance.
The 5-inch/38 functioned as a dual purpose gun. However, this did not mean that it possessed inferior anti-air abilities; as established during 1941 gunnery tests conducted on board North Carolina, the gun possessed the ability to consistently shoot down aircraft flying at, which was twice as far as the effective range of the earlier single purpose 5-inch/25 anti-air gun.
Each 5-inch/38 weighed almost without the breech. The entire mount weighed. It was long overall, had a bore length of, and had a rifling length of. The gun could fire shells at about ; about 4,600 could be fired before the barrel needed to be replaced. Minimum and maximum elevations were −15 and 85 degrees, respectively. The guns' elevation could be raised or lowered at about 15 degrees per second. The mounts closest to the bow and stern could aim from −150 to 150 degrees; the others were restricted to −80 to 80 degrees. They could be turned at about 25 degrees per second.

Smaller weaponry

The remaining weaponry on board the two North Carolinas was composed of differing numbers of 1.1"/75 caliber guns,.50 caliber machine guns, Bofors 40 mm and Oerlikon 20 mm cannons. Although the ships were originally designed to carry only four quadruple 1.1 in and twelve.50 caliber, this was greatly increased and upgraded during the war.
On both ships, two more quadruple sets of 1.1 in guns were added in place of two searchlights amidships. After she was torpedoed in 1942, North Carolina had these removed and ten quadruple sets of 40 mm guns added. Fourteen were present by June 1943, while a fifteenth mount was added on top of the third main turret that November. Washington retained its six 1.1 in quads until the middle of 1943, when ten quad 40 mm guns replaced them. By August, she had fifteen. The two ships carried these through to the close of the war.
The.50 caliber machine guns did not have the range or power needed to combat modern aircraft and were scheduled for replacement by equal numbers of 20 mm guns, but nothing immediately came of the proposal. In fact, both North Carolina and Washington carried 20 mm and.50 caliber guns for most of 1942. In April, North Carolina had, respectively, forty and twelve, while Washington had twenty and twelve. Two months later, the number of 20 mm guns remained the same, but twelve.50 caliber guns had been added. By September, Washington had twenty more 20 mm guns added, for a total of forty, but five were removed—along with all of the.50 caliber guns—shortly thereafter when two quadruple sets of 1.1 in guns were added. In its refit after being torpedoed, North Carolina had an additional six 20 mm guns added and all of its.50 caliber weapons removed. Washington had sixty-four 20 mm weapons by April 1943, prior to one single mount being replaced by a quadruple mount, and North Carolina had fifty-three by March 1944. In April 1945, North Carolina was assigned to have fifty-six 20 mm, while Washington was assigned seventy-five. In August 1945, the ships both had eight twin 20 mm mounts; North Carolina also carried twenty single, while Washington carried one quad and sixty-three single.

Electronics

Both North Carolina and Washington, designed prior to radar, were originally fitted with many fire-control and navigational optical range-finders. The former lasted until 1944, when it was replaced by a Mark 27 microwave radar—though it was supplemented by a Mark 3 main armament fire control radar. The range-finders were removed in favor of additional 20 mm guns sometime between the end of 1941 and mid-1942. In addition, the ships were commissioned with two Mark 38 directors and were originally fitted with a CXAM air search, two Mark 3s and three Mark 4 secondary armament.
By November 1942, North Carolina had an additional Mark 4 and a SG surface search radar added. The normal battleship configuration was present aboard North Carolina in April 1944, with SK and SG radars, a backup SG, and Mark 8s to direct its main battery. All of the Mark 4s remained for the secondary battery, and one of the older Mark 3s was still present, possibly as a backup for the Mark 8s. An SK-2 dish replaced the older SK radar and Mark 12s and 22s superseded the Mark 4s in September of that year. Aside from never receiving an SK-2, Washington was the recipient of similar upgrades.
Both ships underwent extensive refits near the end or after the war. North Carolina received a secondary air search set and a SCR-720 zenith search radar on the forward funnel. At the end of the war, it had an SP surface-search, a SK-2 air-search, a Mark 38 main battery fire control system with Mark 13 and 27 radars, a Mark 37 secondary battery fire control system with Mark 12, 22 and 32 radars, and a Mark 57 smaller weaponry fire control system, with a Mark 34 radar. In March 1946, Washington had a SK fore and a SR aft, a SG both fore and aft, and a TDY jammer.

Propulsion

The ships in the North Carolina class were equipped with four General Electric geared turbines and eight Babcock & Wilcox three-drum express type boilers. The ships' powerplant incorporated several recent developments in turbine equipment, including double helical reduction gears and high-pressure steam technology. North Carolinas boilers supplied steam at and as hot as. To meet the design requirement of, the engine system was originally designed to supply, but the new technologies increased this output to. Despite this increase, the maximum speed for the ships did not change, since the modifications to the powerplant were incorporated later in the design process. The turbines that had already been installed could not fully take advantage of the higher pressure and temperature steam, and so the level of efficiency was not as high as it should have been. When going astern, the engines provided.
The engine system was divided into four engine rooms, all on the centerline. Each room contained a turbine and two boilers, without any division between the boilers and turbines. This was done to limit the risk of capsizing should the ship sustain heavy flooding in the engine rooms. The engine rooms alternated in their layout: the first and third engine rooms were arranged with the turbine on the starboard side and its corresponding boilers on the port, this was reversed in the second and fourth rooms. The forward-most engine room powered the starboard outer shaft, the second turbine drove the outer screw on the port side, the third engine supplied power to the inner starboard propeller, and the fourth turbine drove the port-side inner screw. All four screws had four blades; the two outer propellers were in diameter and the inner pair were wide. Steering was controlled by a pair of rudders.
At the time of their commissioning, the ships had a top speed of, though by 1945, with the addition of other equipment, such as anti-aircraft weaponry, their maximum speed was reduced to. The increases in weight also reduced the ships' cruising range. In 1941, the ships could steam for at a cruising speed of ; by 1945, the range at that speed was reduced to. At, the range was considerably lower, at.
Electrical power was supplied by eight generators. Four were turbo-generators designed for naval use; these provided 1,250 kilowatts each. The other four were diesel generators that supplied 850 kilowatts each. Two smaller diesel generators—each provided 200 kilowatts—supplied emergency power should the main system be damaged. Total electrical output was 8,400 kilowatts, not including the emergency generators, at 450 volts on an alternating current.

Armor

The North Carolina class incorporated "all or nothing" armor which weighed 41% of the total displacement; it consisted of an "armored raft" that extended from just forward of the first gun turret to just aft of the rear gun turret. They had a main armored belt that was thick amidships, inclined at 15°, and backed by Special Treatment Steel. This tapered down to on the lower edge of the belt. The ships had three armored decks; their main deck was thick, the second, thickest deck was of armor laminated on STS for a total of, and the third and thinnest deck was thick. The first deck was designed to cause delay-fuzed projectiles to detonate, while the thicker second deck would protect the ships' internals. The third deck was intended to protect against shell splinters that might have penetrated the second deck; it also acted as the upper support for the torpedo bulkheads. The conning tower was connected to the armored citadel by a thick communications tube. Armor thickness for the conning tower itself ranged from on both sides to on the front and rear. The roof was thick and the bottom was thick.
The main battery turrets were heavily armored: the turret faces were 16-inch thick, the sides were thick, the rear sides were thick, and the roofs were thick. Sixteen–inch-thick armor was the maximum width factories were able to produce at the time of the ships' design; by 1939, however, it was possible to create -thick plates. These were not installed because it was estimated that the conversion would delay completion of the ships by 6 to 8 months. The barbettes that held the turrets were also strongly protected. The front portion was, the sides increased to 16 in, and the rear portion reduced to. The 5-inch gun turrets, along with their ammunition magazines, were armored with STS plates.
The side protection system incorporated five compartments divided by torpedo bulkheads and a large anti-torpedo bulge that ran the length of the "armored raft". The outer two compartments, the innermost compartment and the bulge would remain empty, while the third and fourth compartments would be filled with liquid. The system was reduced in depth at either end by the forward and rear gun turrets. In these areas, the fifth compartment was deleted; instead, there was an outer empty compartment and two liquid-filled spaces, backed by another empty compartment. To compensate for the reduced underwater protection system, these sections received additional armor plating, up to in thickness. The complete system was deep and designed to withstand warheads of up to of TNT. Underwater protection was rounded out by a triple bottom that was deep. The bottom layer was thick and was kept filled with fluid, while the upper thick layer was kept empty. The triple bottom was also heavily subdivided to prevent catastrophic flooding should the upper layer be penetrated.

Service

Construction

Two ships, each to cost about $50 million, were authorized in January 1937. Five shipyards submitted bids to build one of the two planned ships. Three were privately run corporations: Bethlehem Shipbuilding, New York Shipbuilding and Newport News Shipbuilding. The other two, the New York Naval Shipyard and Philadelphia Naval Shipyard, were run by the government. When bids were reviewed, the privately run shipyards' submissions ranged from $46 to 50 million, while their government counterparts came in at $37 million. Newport News was unique among these in refusing any fixed monetary value in favor of a "cost-plus %" price, but this led to the rejection of their bid out of hand.
The bids from private companies were heavily influenced by the legislation of the New Deal. The Vinson-Trammell Act limited profit from a ship's construction to 10 percent, while the Walsh-Healey Public Contracts Act specified a minimum wage and required working conditions for workers. The latter act greatly affected the ability of the navy to acquire steel, as the text of the law caused friction between executives in the industry, who greatly disliked the forty-hour work week and minimum wage requirements, and their workers—who themselves were embroiled in a separate dispute pitting the union of the skilled workers, the American Federation of Labor, against the union of the unskilled, the Congress of Industrial Organizations. Amid the unrest, the navy ran into difficulties trying to acquire 18 million pounds of steel to build six destroyers and three submarines; many more pounds than this would be needed for the new battleships.
The private shipyards, however, had their own labor problems, so much so that one author described the navy's issues as "minimal" compared to their shipbuilding counterparts. This increased the price of the battleships to $60 million each, so the Bureau of Steam Engineering and Bureau of Construction and Repair recommended to their superiors that the $37 million tenders from the two navy yards be accepted. This was confirmed by Roosevelt, as the private shipyards' bids were seen as unjustly inflated. The contracts for North Carolina and Washington—names had been officially chosen on 3 May 1937—were sent to the New York and Philadelphia yards, respectively, on 24 June 1937. Shortly after this announcement, Roosevelt was bombarded with heavy lobbying from citizens and politicians from Camden and the state of New Jersey, in an ultimately futile attempt to have the construction of North Carolina shifted to Camden's New York Shipbuilding; such a contract would keep many men employed in that area. Roosevelt refused, saying that the disparity in price was too great. Instead, the company was awarded two destroyer tenders in December 1937, and.
Construction of the North Carolina class was slowed by the aforementioned material issues, the changes made to the basic design after this date—namely the substitution of 16-inch for 14-inch guns—and the need to add both length and strength to the slipways already present in the navy yards. Increased use of welding was proposed as a possible way to reduce weight and bolster the structural design, as it could have reduced the ships' structural weight by 10%, but it was utilized in only about 30% of the ship. The costs associated with welding and an increase in the time of construction made it impractical.

''North Carolina''

was laid down on 27 October 1937, the first battleship begun by the United States since the never-completed South Dakota class of the early 1920s. Although North Carolina was launched on 13 June 1940 and commissioned on 9 April 1941, she did not go on active duty because of acute longitudinal vibrations from its propeller shafts. A problem shared with its sister Washington and some other ships like, it was only cured after different propellers were tested aboard North Carolina, including four-bladed and cut-down versions of the original three-bladed. This testing required her to be at sea, and the many resulting trips out of New York Harbor to the Atlantic Ocean caused her to be nicknamed "The Showboat".
After a shakedown cruise in the Caribbean Sea and participation in war exercises, North Carolina transited the Panama Canal en route to the Pacific War. Joining Task Force 16, the battleship escorted the aircraft carrier during the invasions of Guadalcanal and Tulagi on 7 August 1942, and continued to accompany the carrier when she moved to be southeast of the Solomons. The Battle of the Eastern Solomons began when Japanese carriers were spotted on 24 August; although American planes were able to strike first by sinking the light carrier, a strike group from a different force, formed around the fleet carriers and, attacked TF 16. In an intense eight-minute battle, North Carolina shot down 7–14 aircraft and was relatively undamaged, though there were seven near-misses and one crewman was killed by strafing. Enterprise took three bomb hits.
North Carolina then joined the carrier s screen, and protected her while support was rendered to American troops fighting on Guadalcanal. Although she dodged one torpedo on 6 September, she was not able to avoid another on the 15th. Out of a six-torpedo salvo from the, three hit the carrier, one hit, one missed, and one struck North Carolina. A warhead hit on the port side below the waterline at a point that was just behind the number one turret. It created a hole, allowed about of water into the ship—which had to be offset with counter-flooding, meaning that another entered—killed five men, and wounded twenty. Although North Carolina could steam at soon after the explosion, she was later forced to slow to to ensure that temporary shoring did not fail. Structural damage beneath the first turret rendered her unable to fire unless in absolute need, and the main search radar failed. As this was the first torpedo to strike a modern American battleship, there was a large amount of interest from various officers and bureaus within the navy in learning more about it. The conclusions were seen as a vindication by some who believed that too much had been sacrificed in the design of the North Carolinas—the torpedo defense system had come close to breaking near one of the most important areas of the ship, after all—and the General Board called for the fifth and sixth s, and, to have a torpedo bulge added outside their magazines. However, the new Bureau of Ships opposed this on the basis that the system performed as it was supposed to; in any case, no modifications were made.
Repaired and refitted at the facilities in Pearl Harbor, North Carolina operated as a carrier escort for Enterprise and Saratoga for the remainder of 1942 and the majority of 1943 while they provided cover for supply and troop movements in the Solomons. In between, she received advanced fire control and radar gear in March, April and September 1943 at Pearl Harbor. In November, North Carolina escorted Enterprise while the carrier launched strikes upon Makin, Tarawa and Abemama. On 1–8 December she bombarded Nauru before returning to carrier screening; she accompanied while that carrier launched attacks on Kavieng and New Ireland.
Joining Task Force 58 in January 1944, North Carolina escorted aircraft carriers as the flagship of Vice Admiral Willis A. Lee, Commander, Battleships, Pacific Fleet for much of the year, providing support for airborne strikes on Kwajalein, Namur, Truk, Saipan, Tinian, Guam, Palau, Woleai, and Hollandia in January–April. Also in April, North Carolina destroyed defensive installations on Ponape before setting course for Pearl Harbor for repairs to a damaged rudder. With repairs completed, the battleship joined with Enterprise on 6 June for assaults within the Marianas; as part of these, North Carolina used its main battery to bombard Saipan and Tanapag.
In late June, North Carolina was one of the American ships which took part in the so-called "Marianas Turkey Shoot", where a majority of attacking Japanese aircraft were shot down out of the air at little cost to the American defenders. Problems with its propeller shafts then caused the battleship to sail to the Puget Sound Navy Yard to receive an. She returned to active duty in November and to its carrier escort tasks in time to be hit by a typhoon. North Carolina protected carriers while they provided air cover for invasion fleets and launched attacks on Leyte, Luzon, and the Visayas. Surviving another typhoon, one which sank three destroyers, North Carolina continued escort duty when naval aircraft struck Formosa, Indo-China, China, the Ryukyus and Honshu in January and February 1945. During the invasion of Iwo Jima, the battleship provided bombardment support for troops ashore.
During the assault on Okinawa, North Carolina screened carriers and bombarded targets ashore. Although she was able to shoot down three kamikazes on 6 April, she also was struck by a shell during that time in a friendly fire incident; three were killed and forty-four injured. The battleship shot down a plane on the 7th and two on the 17th. After receiving another overhaul from 9 May to 28 June, this one in the naval yard at Pearl Harbor, North Carolina operated as both a carrier escort and shore bombardier for the remainder of the war. Of note was a 17 July bombardment of the industrial area in Hitachi, Ibaraki in company with fellow battleships,, and, along with smaller warships.
In August, members of North Carolinas crew and Marine contingent were sent ashore to assist in occupying Japan. After the official surrender, these men were brought back aboard and the battleship sailed to Okinawa. As part of Operation "Magic Carpet", soldiers were embarked to be returned to the United States. Passing through the locks of Panama Canal on 8 October, she weighed anchor in Boston on the 17th. After an overhaul in the New York Naval Yard, she participated in exercises off New England before beginning a midshipman training cruise in the Caribbean.
North Carolina was decommissioned in Bayonne, New Jersey on 27 June 1947; she remained in the reserve fleet in until 1 June 1960, when she was from the Naval Vessel Register. Instead of the scrapping that faced most of the United States' battleships, North Carolina was sold to the state of North Carolina for $250,000 on 8 August 1961 to be a museum ship. She was dedicated in Wilmington on 29 April 1962 as a memorial to the citizens of the state who died in the Second World War. Listed on the United States' National Register of Historic Places and designated as a National Historic Landmark on 1 January 1986, she remains there today, maintained by the USS North Carolina Battleship Commission.

''Washington''

was laid down on 14 June 1938, launched on 1 June 1940 and commissioned on 15 May 1941 at the Philadelphia Naval Shipyard. Although commissioned, her engine had not been run at full power—like her sister, Washington had major problems with longitudinal vibrations, which were only tempered after many tests conducted aboard North Carolina. The fixes made it possible to run builder's trials, which Washington did on 3 August 1941; loaded at about, the propulsion plant was run up to, and repeated the performance again in February 1942, achieving.
In early 1942 Rear Admiral John W. Wilcox chose Washington as the flagship of Task Force 39. On 26 March 1942, Washington, along with Wasp,, and various smaller ships, sailed to bolster the British Home Fleet. During the voyage, Wilcox fell into the ocean; he was seen soon after by the destroyer, face down in the water, but due to rough seas they were unable to retrieve the body. It is not known what exactly happened; he could have simply been caught by a wave and washed overboard, but there has been speculation that he suffered a heart attack. The force reached the main anchorage of the Home Fleet, Scapa Flow, on 4 April.
Washington and the other ships of TF 39 participated in exercises with the Home Fleet until late April. Along with certain British units, the task force departed the British Isles as TF 99. They escorted some of the Arctic convoys which were carrying vital cargo to the Soviet Union. While carrying out this duty, an accompanying British battleship, HMS King George V, accidentally rammed a destroyer, cutting it in two. Directly behind King George V, Washington passed through the same stretch of sea and received damage from exploding depth charges. Though damage to the hull was minimal—limited to only one leaking fuel tank—many devices on board the ship were damaged, including main battery range finders, circuit breakers, three fire-control and the search radars. The American ships then put in at an Icelandic port, Hvalfjörður, until 15 May; they returned to Scapa Flow on 3 June. On 4 June, Washington hosted the commander of naval forces in Europe, Admiral Harold Rainsford Stark, who set up a temporary headquarters on the ship for the next few days. On 7 June, King George VI of the United Kingdom inspected the battleship.
on board Washington, 7 June 1942; an OS2U Kingfisher is in the background
Washington left the North Sea bound for the United States on 14 July with an escort of four destroyers; upon arrival at the New York Naval Yard on the 23rd, she was given a full overhaul which took a month to be completed. She set sail for the Panama Canal and the Pacific Ocean on 23 August and reached her destination, Tonga Island, on 14 September, where she became the flagship of Admiral Willis "Ching" Lee. Over the coming months, Washington would be focused upon the safe arrival of supply convoys to the men fighting on Guadalcanal. On 13 November, three formations of Japanese ships were discovered on course for Guadalcanal, one of them aiming to bombard Henderson Field while night gave them protection from aircraft. The first Japanese bombardment force was driven back by an American cruiser-destroyer force. On 14 November, the Japanese organized another sortie to neutralize the airfield. Washington,, and four destroyers were sent to intercept the Japanese force that night. The Japanese, composed of the fast battleship, two heavy cruisers, two light cruisers, and nine destroyers, initially sank three US destroyers and inflicted significant topside damage to South Dakota. However, Washington remained undetected and at midnight fired on Kirishima from, point blank range for Washingtons 16-inch/45-caliber guns. Washington fired seventy-five 16-inch and one hundred and seven 5-inch rounds during the melee, scoring 20 main and seventeen secondary battery hits, knocking out Kirishima's steering and main battery and causing uncontrollable progressive flooding. Kirishima capsized at 03:25 on the morning of 15 November 1942, with 212 crewmen lost. Radar-directed fire from Washingtons secondary battery also damaged destroyer so severely it had to be scuttled. Soon after the battle, the Japanese began evacuating Guadalcanal.
Until April 1943, Washington stayed near her base in New Caledonia, providing protection for convoys and battle groups that were supporting the Solomons campaign. Returning to Pearl Harbor, she practiced for battle and underwent an overhaul before returning to the combat zone in late July. From August to the end of October, Washington operated out of Efate. She then joined with four battleships and six destroyers as Task Group 53.2 for exercises; Enterprise, and also participated. TG 52.2 then voyaged to the Gilbert Islands to add additional firepower to the strikes currently hitting them. Departing in late November, Washington first steamed to Makin to provide protection for ships there, then Ocean Island to prepare to bombard Nauru with her sister North Carolina, all four South Dakota-class battleships, and the carriers Bunker Hill and. All of the capital ships struck before dawn on 8 December; the aircraft carriers struck again soon after. The ships then sailed back to Efate, arriving on 12 December. On Christmas, Washington, North Carolina, and four destroyers left Efate for gunnery practice. By late January, she was made part of TG 50.1 to escort the fast carriers in that group as they launched strikes on Taroa and Kwajalein. She also moved in to hit Kwajalein with her guns on 30 January.
Before dawn on 1 February, with the sky still shrouded in darkness, Washington collided with when the latter left formation to fuel four destroyers. Indiana had radioed that she was going to make a turn to port out of the formation, but soon after starting the turn, her captain ordered a reversal, back to starboard. About seven minutes later, she came into view of lookouts aboard Washington at a range of. Although crews on both ships frantically tried to avoid the other, it was to no avail; Washington gave Indiana a glancing blow, scraping down a large aft portion of the ship's starboard side. Washingtons fore end was severely damaged, with about of her bow hanging down and into the water. Ten men, six from Washington, were killed or listed as missing. After temporary reinforcements to the damaged section, she was forced to sail to Pearl Harbor to be fitted with a false bow to make possible a voyage to Puget Sound. Once there, she received a full overhaul, along with a new bow; this work lasted from March until April. Washington did not enter the war zone again until late May.
Washington next participated in the Mariana and Palau Islands campaign, serving again as a carrier escort ship, though she was detached on the 13th to fire on Japanese positions on Saipan and Tinian. With the sortie of a majority of the remaining ships in the Imperial Japanese Navy spotted by American submarines, Washington, along with six other battleships, four heavy cruisers and fourteen destroyers covered the aircraft carriers of TF 58; on the 19th, with the attack of many aircraft, the Battle of the Philippine Sea began. Able to beat off the attacks, Washington refueled and continued escorting carriers until she, with three battleships and escorts, formed a new task group. After a lengthy stop at Enewetak Atoll, she supported troops assaulting Peleliu and Angaur before returning to screening duties. This duty lasted from 10 October to 17 February 1945.
The battleship bombarded Iwo Jima from 19–22 February in support of the invasion there before escorting carriers which sent aircraft raids against Tokyo and targets on the island of Kyūshū. On 24 March and 19 April, Washington bombarded Okinawa; she then departed for Puget Sound to receive a refit, having been in action for the majority of the time since its refit in March–April 1944. This lasted through V-J Day and the subsequent formal ceremony aboard Missouri, so Washington received orders to voyage to Philadelphia, where she arrived on 17 October. Here she was modified to have an additional 145 bunks, so that she could participate in Operation Magic Carpet. Sailing to Southampton with a reduced crew of 84 officers and 835 crew, she brought 185 army officers and 1,479 enlisted men back to the United States; this was the only voyage she would make in support of the operation. The battleship was placed into reserve at Bayonne, New Jersey on 27 June 1947, after only a little more than six years of service. Washington was never reactivated. Struck from the Naval Vessel Register on 1 June 1960—exactly 21 years to the day since her launch—she was sold on 24 May 1961 to be scrapped.

Post-war alterations and proposals

North Carolina and Washington remained in active duty in the years immediately after the war, possibly because they were more comfortable and less cramped than the four South Dakotas. The ships received alterations during this period; the Ship Characteristics Board directed in June 1946 that four of the quadruple-mounted 40 mm guns be removed, though only two were actually taken off each ship. The 20 mm weapons were also reduced at some point so that both ships were decommissioned with sixteen twin mounts. North Carolina and Washington were decommissioned on 27 June 1947 and subsequently moved to the reserve fleet.
In May 1954, SCB created a class improvement plan for the North Carolinas which included twenty-four 3-inch/50 guns directed by six Mark 56s. A month later, the SCB chairman voiced his belief that the North Carolinas and South Dakotas would be excellent additions to task forces—if they could be faster. The Bureau of Ships then considered and discarded designs that would move these ships at, four knots faster than their current attainable speed. In order for a North Carolina to obtain 31 knots, would be required. This, in turn, would necessitate the installation of an extremely large power plant, one which would not fit into the ship even if the third turret was removed. If the outer external belt armor were removed, would still be required. However, no matter if the belt was taken off or not, all of the hull form aft would have to be greatly modified to accept larger propellers. The last strike against the project was the high estimated cost of $40 million—which did not include the cost of activating battleships that had been out of commission for ten years.
Later calculations proved that the North Carolinas could be lightened from 44,377 long tons to around, at which 210,000 shp would suffice. At the trial displacement figure of, even would be enough; the 210,000 figure was derived from a 12.5% overestimation to account for a fouled bottom or bad weather. A similar power plant to the one used in the Iowa class would be enough, and if the third turret was removed there would be no problems with weight, but there was not enough space within the North Carolinas. When compared, the current power plant measured, but Iowas was. Lastly, there would be an issue with the propellers; the Iowa class' were wide, while the North Carolinas were. In the end, no conversions were undertaken.
Designs for helicopter carriers also contained a plan for a conversion of the North Carolinas. At a cost of $30,790,000, the ships would have been able to embark 28 helicopters, 1,880 troops, of cargo and of oil. All of the 16-inch and 5-inch guns would have been removed, though the number one turret would have remained so that weights added on the stern half of the ship could be balanced. In place, the ships would have received sixteen 3-inch guns in twin mounts. Displacement would be lowered slightly to a fully loaded weight of about, while speed would not have changed. It was estimated that the ships could serve for about fifteen to twenty years at a cost of about $440,000 a year for maintenance. However, it was found that a purpose-built helicopter carrier would be more economical, so the plans were shelved.

Ships of the class

Ship NameHull No.BuilderLaid DownLaunchedCommissionedDecommissionedFate
North CarolinaBB-55New York Naval Shipyard27 October 193713 June 19409 April 194127 June 1947Struck 1 June 1960; Museum ship since 29 April 1962 Wilmington, North Carolina
WashingtonBB-56Philadelphia Naval Shipyard14 June 19381 June 194015 May 194127 June 1947Struck 1 June 1960; Sold for scrap, 24 May 1961

Endnotes

Web

  • DiGiulian, Tony. "." NavWeaps. Accessed 15 November 2009.
  • DiGiulian, Tony. "." NavWeaps. Accessed 15 November 2009.
  • Haworth, R.B. ".". Miramar Ship Index. Accessed 15 November 2009.
  • Haworth, R.B. ".". Miramar Ship Index. Accessed 15 November 2009.
  • "." Online Library of Selected Images, Naval History & Heritage Command. Accessed 15 November 2009.
  • "." Naval Vessel Register, Department of the Navy. Accessed on 15 November 2009.
  • "." Naval Vessel Register, Department of the Navy. Accessed 15 November 2009.

    Primary

  • " ". London: Third London Naval Conference, 25 March 1936.